VX-7R_s.pdf
(
7974 KB
)
Pobierz
.....p65
50/144/430 MHz Triple-Band
Heavy Duty Submersible Transceiver
VERTEX STANDARD CO., LTD.
4-8-8 Nakameguro, Meguro-Ku, Tokyo 153-8644, Japan
VERTEX STANDARD
US Headquarters
10900 Walker Street, Cypress, CA 90630, U.S.A.
YAESU EUROPE B.V.
P.O. Box 75525, 1118 ZN Schiphol, The Netherlands
YAESU UK LTD.
Unit 12, Sun Valley Business Park, Winnall Close
Winchester, Hampshire, SO23 0LB, U.K.
VERTEX STANDARD HK LTD.
Unit 5, 20/F., Seaview Centre, 139-141 Hoi Bun Road,
Kwun Tong, Kowloon, Hong Kong
VX-7R
Technical Supplement
©2003 VERTEX STANDARD CO., LTD.
EH009M90B
DW
Introduction
This manual provides the technical information necessary for servicing
the VX-7R 50/144/430 MHzTriple-Band Heavy Duty Submersible Trans-
ceiver.
Servicing this equipment requires expertise in handing surface-mount
chip components. Attempts by non-qualified persons to service this
equipment may result in permanent damage not covered by the war-
ranty, and may be illegal in some countries.
Two PCB layout diagrams provided for each double-sided board in
this transceiver. Each side of the board is referred to by the type of the
majority of components installed on that side ("Side A" or "Side B"). In
most cases one side has only chip components, and the other has either
a mixture of both chip and leaded components (trimmers, coils, electro-
lytic capacitors, ICs, etc.), or leaded components only.
While we believe the information in this manual to be correct, VER-
TEX STANDARD assumes no liability for damage that may occur as a
result of typographical or other errors that may be present. Your coop-
eration in pointing out any inconsistencies in the technical information
would be appreciated.
Contents
Specification ............................................................................................................................................ 2
Exploded View & Miscellaneous Parts .............................................................................................4
Block Diagram ........................................................................................................................................ 5
Interconnection Diagram ...................................................................................................................... 6
Circuit Description ................................................................................................................................ 7
Alignment .............................................................................................................................................. 11
Board Unit (Schematics, Layouts & Parts)
RF Unit ............................................................................................................................................................................. 19
AF Unit ............................................................................................................................................................................ 33
CNTL Unit ....................................................................................................................................................................... 45
VCO Unit ......................................................................................................................................................................... 59
1
Specifications
General
Frequency Ranges:
Rx (MAIN):
0.5 - 1.8 MHz (BC Band)
1.8 - 30 MHz (SW Band)
30-59 MHz (50 MHz HAM: USA version)
30-76 MHz (50 MHz HAM: EXP version)
59-108 MHz (FM: USA version)
76-108 MHz (FM: EXP version)
108-137 MHz (Air Band)
137-174 MHz (144 MHz HAM)
174-222 MHz (VHF-TV)
222-225 MHz (220 MHz HAM: USA version)
225-420 MHz (ACT1: Action Band 1: USA version)
222-420 MHz (ACT1: Action Band 1: EXP version)
420-470 MHz (430 MHz HAM)
470-729 MHz (UHF-TV: USA version)
470-800 MHz (UHF-TV: EXP version)
800-999 MHz (ACT2: Action Band 2, cellular Blocked)
Rx (SUB):
50 - 54 MHz
137 - 174 MHz
420 - 470 MHz
Tx: 50 - 54 MHz (MAIN & SUB)
144 - 146 MHz or 144 - 148 MHz (MAIN & SUB)
222-225 MHz (MAIN, USA version)
430 - 440 MHz or 430 - 450 MHz (MAIN & SUB)
5/9/10/12.5/15/20/25/50/100 kHz
±5 ppm (+14°F to +122°F, –10°C to +50°C)
F2, F3, A3
50-ohm
Nominal: 7.4 V DC, Negative Ground
Operating: 10 - 16 V DC, Negative Ground (
EXT DC
jack)
150 mA (Mono Band Receive)
200 mA (Dual Band Receive)
55 mA (Mono Band Receive, Standby, Saver Off)
100 mA (Dual Band Receive, Standby, Saver Off)
25 mA (Mono Band Receive, Standby, Saver On "Save Ratio 1:5")
50 mA (Dual Band Receive, Standby, Saver On "Save Ratio 1:5")
400 µA (Auto Power Off)
1.6/1.3/1.0/0.7 A (50 MHz, Tx HI/L3/L2/L1)
1.71.4/1.1/0.8 A (144 MHz, Tx HI/L3/L2/L1)
0.6 A (220 MHz, Tx)
1.8/1.5/1.2/0.9/ A (430 MHz, Tx HI/L3/L2/L1)
–4°F to +140°F (–20°C to +60°C)
60 (W) x 90 (H) x 28 (D) mm (w/o knob & antenna)
250 g
Channel Steps:
Frequency Stability:
Emission Type:
Antenna Impedance:
Supply Voltage:
Current Consumption:
Operating Temperature:
Case Size:
Weight:
2
Specifications
Transmitter
RF Power Output:
5/2.5/1.0/0.5 W (50/144/430 MHz, FM)
0.3 W (220 MHz, FM)
1.0 W (50 MHz, FM)
FM: Variable Reactance
AM: Early Stage (Low Level)
±5/±2.5 kHz
At least 60 dB below (@ Tx 1W)
2 k-ohm
Modulation Type:
Maximum Deviation:
Spurious Emission:
Microphone Impedance:
Receiver
Circuit Type:
N-FM, AM: Double-Conversion Superheterodyne
W-FM: Triple-Conversion Superheterodyne
1st: 47.25 MHz (N-FM, AM)
45.8 MHz (W-FM)
2nd: 450 kHz (N-FM, AM)
10.7 MHz (W-FM)
3rd: 1 MHz (W-FM)
3.0 µV for 10 dB SINAD (0.5 - 30 MHz, AM)
0.5 µV for 12 dB SINAD (30 - 50 MHz, N-FM)
0.16 µV for 12 dB SINAD (50 - 54 MHz, N-FM)
15 kHz/35 kHz (-6 dB/-60 dB: N-FM, AM)
200 kHz/300 kHz (-6 dB/-20 dB: W-FM)
200 mW @ 8 ohm for 10 % THD (@ 7.4V DC)
400 mW @ 8 ohm for 10 % THD (@ 13.8V DC)
Intermediate Frequencies:
Sensitivity:
Selectivity:
AF Output:
Specifications are subject to change without notice, and are guaranteed within amateur bands only.
3
Exploded View & Miscellaneous Parts
U9900137 BINDING HEAD SCREW M2X21.7 (W/ O RING)
2
RA0417100
PANEL FRAME
U9900138 BINDING HEAD SCREW M2X5 (W/ O RING)
4
U07225120 PAN HEAD SCREW M2X2.5SUS#1
4
U9900136 SPECIAL SCREW M2X2.35
1
RA0304300 WASHER
1
RA0399500
WINDOW
U00103002 PAN HEAD SCREW M2X3NI
1
U00104002 PAN HEAD SCREW M2X4NI
6
RA0399400
DOUBLE FACE TAPE
U9900140 TAPTITE SCREW M2X6SUS#3
2
U44104002 TAPTITE SCREW M2X4NI
4
U9900141 TAPTITE SCREW M1.7X5NI#3
2
RA0401600
O RING
U07125102 TAPTITE SCREW M1.7X2.5SUS#1
2
CP7346002 (USA, SILVER)
CP7346003 (EXPORT, SILVER)
CP7346004 (GERMANY, SILVER)
CP7346006 (USA, BLACK)
CP7346007 (EXPORT, BLACK)
CP7346008 (GERMANY, BLACK)
PANEL ASS’Y
with RUBBER KNOB, MIC SHEET,
SP SHEET, SP, PROTECTOR L,
PROTECTOR R
RA0399800
LIGHT GUIDE (LED)
Q7000426
LCD MODULE
RA0400000
RUBBER PACKING
RA0399100
LIGHT GUIDE (LED)
RA014250A
DOUBLE FACE TAPE (LCD)
RA0399900
REFLECTOR SHEET
SUPPLIED ACCESSORIES
VXSTD P/N
DISCRIPTION
Q3000183
YHA-64
RA0405600
MIC HOLDER RUBBER
(depending on transceiver version)
Q3000185
YHA-65
Q8101014
YHA-63 50MHZ ADAPTER L
Q8101015
YHA-63 440MHZ ADAPTER S
Q9000786
LI-ION BATTERY FNB-80LI
Q9500087
NC-72A
CNTL-Unit
Q9500088
NC-72B
(depending on transceiver version)
Q9500089
NC-72C
Q9500090
NC-72U
RA029630A
BELT CLIP
S6000335
HAND STRAP
AF-Unit
P1091150
CONNECTOR (MIC/SP)
FR008330C
FPC CABLE
RA0426800
O RING
RA0400200
STUD (X4 pcs)
There is a direction in
WASHER.
RA0400900
O RING
P0091335
CONNECTOR (EXT DC)
SCREW
RF-Unit
RA01403AA
LATCH NAIL
WASHER
RA0400500
EXT CAP
EXP CAP
CP7342003 (SILVER)
CP7342005 (BLACK)
REAR CASE ASS’Y
with SMA CONNECTOR ASS’Y,
TERMINAL BOARD ASS’Y,
RUBBER HOLDER (PTT),
RUBBER KNOB (PTT)
RA0292200
SPECIAL NUT
RA0426900
O RING
RA0087900
SPECIAL NUT
RA0399700
HOLDER (PTT)
RA0401200
ENCODER KNOB
RA0400100
RUBBER KNOB (PTT)
RA0140100
MASK SHEET
RA0401900
VOLUME KNOB
RA0400600
CAP(SP/MIC)
RA0141600
RUBBER PACKING
FNB-80LI
4
Block Diagram
5
Plik z chomika:
exti
Inne pliki z tego folderu:
VX7Cmd134(1).zip
(2446 KB)
Ikona PMR.vxi
(0 KB)
Usuwanie komórki pamięci.txt
(0 KB)
plug.gif
(2 KB)
VX-7R.pdf
(3988 KB)
Inne foldery tego chomika:
Amatorskie anteny
Częstotliwości lotnicze KF
Degen DE1103
Instrukcje do skanerów i TRX-ów
Programy
Zgłoś jeśli
naruszono regulamin